Product ID:200 FLUID 10,000 CST
MSDS Date:01/20/1986
FSC:9150
NIIN:00N031640
MSDS Number: BPLMG

Emergency Phone: 517-496-5900

Info Phone: 517-496-6000

Preparer: JACK L.SHENEBERGER

Cage: 5D028

Telephone: 517-496-4388

Cage: 71984

SILICON FLUID(SILICONE).

CAS: 63148-62-9

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE TEMPORARY DISCOMFORT.
SKIN: SINGLE, PRLNGD EXPOSURE CAUSES NO KNOWN ADVERSE EFFECT.
INHAL:NO IRRITATION TO NOSE/THROAT EXPECTED. NO INJURY LIKELY FROM
RELATIVELY SHORT EXPOSURE. INGEST:A MOUNTS TRANSFERRED TO MOUTH BY
FINGERS,ETC., DURING NORMAL OPERATIONS SHOULD NOT CAUSE INJURY. NO
KNOWN(EFTS OF OVEREXP
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:ADVERSE CHRONIC HEALTH EFFECTS BUT
UNNECESSARY EXPOSURE TO ANY CHEMICAL SHOULD BE AVOIDED. THIS PROD,
AS W/ANY CHEMICAL, MAY ENHANCE ALLERGIC CONDITIONS ON CERTAIN
PEOPLE.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:EYE:FLUSH W/WATER FOR AT LEAST 15 MINUTES. SKIN:WIPE OFF AND
FLUSH W/WATER. INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O2/ARTFICIAL RESPIRATION), CALL MD . INGEST:GET MD IMMEDIATELY .

Flash Point Method:OC
Flash Point:610F,321C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN TO DOW CORNING.

Spill Release Procedures:USE ABSORB MATL TO COLLECT & CONTAIN FOR
SALVAGE/DISP. PROD IS OIL IN CONTEXT OF U.S. CLEAN WATER ACT.
SPILLS TO U. S. SURF WATERS/TO WATERCOURSES/SEWERS LEADING TO U.S.
SURF WATERS THAT CAUSE VISIBLE SHEEN MUST BE REPORTED TO NAT'L
RESPONSE CTR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE REASONABLE CARE & CAUTION. AT
ELEVATED TEMPS, PROD IS SENSITIVE TO CONTAMINATION.
Other Precautions:IF PROD BECOMES CONTAMD W/STRONG ACIDS, BASES, SOME
METALLIC CMPDS & OXIDIZING AGENTS, FLASH POINT & VISCOSITY MAY
CHANGE & SHOULD BE REDETERMINED. TRACES OF FORMALDEHYDE & OTHER
THERMAL DECOMP PRODS MAY FORM AT TEMPS ABOVE 150C (SUPP DATA)

Respiratory Protection:NO RESPIRATORY PROTECTION REQUIRED. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:MECHANICAL (GENERAL): RECOMMENDED. LOCAL EXHAUST: NONE.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GOOD PRACTICE REQ GROSS AMT OF ANY CHEM BE
REMOVED FROM SKIN AS SOON AS PRACTICAL, ESPECIALLY BEFORE EATING OR
SMOKING.
Supplemental Safety and Health
OTHER PREC:IN THE PRESENCE OF AIR. PROVIDE ADEQUATE VENTILATION WHEN
HANDLING AT ELEVATED TEMPERATURES.

HCC:V6
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<5 @ 77F
Spec Gravity:0.98
Evaporation Rate & Reference:< 1 (ETHER = 1)
Solubility in Water:< 0.1%
Appearance and Odor:LIQUID, NO COLOR, VERY LITTLE ODOR.
Percent Volatiles by Volume:<5

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Hazardous Decomposition Products:SILICON DIOXIDE, CO2 AND TRACES OF
INCOMPLETELY BURNED CARBON PRODUCTS.

Waste Disposal Methods:DOW CORNING SUGGESTS THAT ALL LOCAL, STATE &
FEDERAL REGS CONCERNING HLTH & POLLUTION BE REVIEWED TO DETERMINE
APPRVD DISP PROCEDURES. CNTCT DOW CORNING IF THERE ARE ANY DISPOSAL
QUESTIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.